Select Language
English
中文版
Italia
русский
tiếng Việt
ภาษาไทย
Melayu
हिंदी
Pilipino
العربية
Français
español
Browse Categories
Tank truck(74)
Water truck(95)
Pressure vessel(LPG truck)(37)
Fire truck(31)
Dump Truck(25)
Garbage truck(105)
Bulk cement truck(23)
Concrete mixer truck(31)
Tow truck(50)
Van truck(137)
Contact us
Tel: 0086-0722-3229933
Fox: 0086-0722-3229933
Email: cj001@urspv.com
Add: Starlight industrial park, Northern suburbs, Suizhou city, hubei province, C...
Contact Now
Home > News > Industry News > Dump Truck Safety Technology

News

Dump Truck Safety Technology

  • Author:Chang Jie
  • Release on :2016-11-28

1. Dump truck drivers should be licensed to enter the city traffic or highway, must comply with traffic laws and regulations.
2. Prior to start should focus on inspection. Lighting, speakers, indicating instruments should be complete; fuel, lubricants, cooling water should be added enough; the connection shall not loose; tire pressure should meet the requirements, confirm correct before starting. Fuel tank should be locked1. Dump truck drivers should be licensed to enter the city traffic or highway, must comply with traffic laws and regulations.
2. Prior to start should focus on inspection. Lighting, speakers, indicating instruments should be complete and complete; fuel, lubricants, cooling water should be added enough;
the connection shall not loose; tire pressure should meet the requirements, confirm correct before starting. Fuel tank should be locked.
3. After starting, should observe the instrument instruction value, check the internal combustion engine operation, test steering mechanism and brake performance, confirm the normal and the water temperature reaches 40 ℃ above, the brake pressure to safety pressure above, before low-grade start. Before the start, next to the car and the car should
be no obstacles and personnel.
4 water temperature does not reach 70 ℃, not high speed. Driving, the change should be gradually increase or decrease this time, the correct use of the clutch, not a strong push hard pull, so that the impact of gear ring. Forward and back alternating, the car should be stopped after a stable shift.
5. Driving, the instrument should be observed at any time the instructions, when the oil pressure is lower than the specified value, the water temperature is too high or abnormal sound, odor and other unusual circumstances, should immediately stop inspection, troubleshooting, continue to run.
6. Speeding is strictly prohibited. Should be based on speed and the vehicle in front to maintain an appropriate safety distance, choose a better road, should avoid stones, nails or other sharp iron. In case of pits, ditches or through the railway, should be slowed down in advance. Slow through.
7. On, downhill should be replaced in advance into the low gear, not halfway shift. Downhill, the engine resistance should be to control the speed, if necessary, can be intermittently light riding the brake. Do not slide the clutch or neutral.
8. In the muddy, ice and snow on the road, should reduce the speed, should follow the previous car rut forward, if necessary, anti-skid chain should be installed.
9. When the vehicle into the pit, sand nest when. Do not use the loose clutch pedal approach to the impact of the start. When using the differential lock should be low-speed
straight line, not turning.
10. For non-jack-up operation, the lift-up lever should be in the neutral position. Before lifting, should be set aside car fixed pin. After the job, insert the carriage fixing pin.
11. Dredging machinery with the loading, the dump truck in place should be tightened after the hand brake, the bucket needs to be more than the cab, the cab is strictly prohibited.
12. Before discharge, there should be no wires or obstructions on the top of the dump truck compartments. When unloading. Should stop the car, not while unloading side of the
road. When lifting the car, should control the internal combustion engine in the speed of operation, when the car rose to the vertex, should reduce the internal combustion engine speed, reduce the car vibration.
13. When discharging to the pothole area, keep a safe distance from the pit and prevent the landslide from overturning. Do not dump sideways on the slope.
14. After unloading, the car should be reset in time to start, not in the case of tilt driving. Is strictly prohibited in the carriage.
15. After lifting the car to be carried out maintenance, lubrication and other operations, the carriage should be firmly secured before entering the car below the work.